好看的小说完本推荐,完美世界txt下载

站內搜索

新聞資訊

公司新聞行業動態

熱點

自動上料平口攪拌機多種方量可供選擇

2022-12-23

混凝土自動上料攪拌車的功能有哪些？

2022-12-19

混凝土自動拌料車移動式可自行走戶外施工

2022-12-16

自上料攪拌車企業這么多，買車的時候應該看哪方面？

2022-12-12

關于山汽

聯系人：劉老師

電話：400-879-1999

公司：山東山汽工程機械（集團）有限公司

地址：山東省萊州市206國道與308省道交叉口東南50米

自動攪拌一體機要想上路需要注意什么

所屬分類：公司新聞發布時間：2021-11-11 來源：http://klalyy.cn/ 瀏覽量：0

自動攪拌一體機是一個特種攪拌設備，要想上路務必要小心小心再小心，下面我們來看下都需要注意哪些事項；

The automatic mixing machine is a special mixing equipment. If you want to go on the road, you must be careful again and again. Let's take a look at what we need to pay attention to;
自動攪拌一體機

1、自動攪拌一體機運輸混凝土過程中如車輛發生故障，出現罐體停轉現象時，請按如下操作方法施救：（1）應檢查是否為操縱機構故障，擺動操縱手柄觀察油泵擺桿是否發生變化；（2）若操縱機構無異常，應嘗試采用應急油管進行施救；若應急油管施救無效，則需要立即打開罐體檢修孔將混凝土清理出來；若檢修孔位置不合適，必須在前錐適當位置使用氣割緊急開孔，然后以快的速度將罐內混凝土清理出來。

1. If the vehicle breaks down and the tank stops running during the transportation of concrete by the automatic mixer, please rescue according to the following operation methods: (1) first check whether it is the fault of the control mechanism, swing the control handle and observe whether the swing rod of the oil pump changes; (2) If the operating mechanism is normal, try to use emergency oil pipe for rescue; If the rescue of the emergency oil pipe is invalid, the tank physical repair hole shall be opened immediately to clean the concrete; If the position of the manhole is inappropriate, gas cutting must be used at the appropriate position of the front cone for emergency opening, and then the concrete in the tank shall be cleaned out as soon as possible.

2、自動攪拌一體機從混凝土入罐到排出，氣溫高時，2小時內盡量排出，陰雨天氣溫度低時，不宜超過3小時。

2. When the temperature is high, the concrete shall be discharged as far as possible within 2 hours. When the temperature is low in cloudy and rainy weather, it shall not exceed 3 hours.

3、自動攪拌一體機在排出混凝土之前，應使攪拌筒高速轉動1分鐘，再進行排料。

3. Before discharging concrete, the automatic mixer shall rotate the mixing drum at high speed for 1 minute before discharging.

4、自動攪拌一體機出料完畢，應立即用隨車的軟管放水，將進料口、出料斗及出料溜槽等部位沖洗干凈，排去粘結在車身各處的混凝土，再向攪拌筒內注水150-200L的清水。在返回途中要讓攪拌筒慢速轉動，以清洗內壁，避免殘余料渣附在筒壁和攪拌葉片上，在下一次裝料前將這些水放掉。

4. After the discharge of the automatic mixing machine, drain the water with the hose on the vehicle immediately, wash the feed inlet, discharge hopper and discharge chute, drain the concrete bonded to the vehicle body, and then inject 150-200l of clean water into the mixing drum. On the way back, the mixing drum shall rotate slowly to clean the inner wall, avoid residual slag attached to the drum wall and mixing blades, and drain the water before the next loading.

5、自動攪拌一體機運送混凝土時，車速不得超過40km/h，以保證行車。

5. When the automatic mixer transports concrete, the speed shall not exceed 40km / h to ensure driving safety.

6、自動攪拌一體機工作完畢，應把攪拌筒內部和車身清洗干凈。

6. After the automatic mixing machine is completed, the interior of the mixing drum and the vehicle body shall be cleaned.

7、自動攪拌一體機水箱的水量要經常保持裝滿，以備急用，冬季停機后，應將水箱、水泵、水管、攪拌筒內的水放凈，并停放在朝陽、不積水的地方，以免凍壞機械。

7. The water volume of the water tank of the automatic mixing integrated machine shall be kept full for emergency use. After shutdown in winter, the water in the water tank, water pump, water pipe and mixing drum shall be drained and parked in the sunny place without ponding to avoid freezing the machine.
自動攪拌一體機

8、檢修自動攪拌一體機液壓傳動部分時，應使發動機和液壓泵在沒有壓力的情況下進行。

8. When overhauling the hydraulic transmission part of the automatic mixing machine, the engine and hydraulic pump shall be operated without pressure.

9、檢修自動攪拌一體機時，如需入罐操作，務必保證車輛熄火并拔出鑰匙，防止誤操作引起人員傷亡。

9. When repairing the automatic mixing machine, if it is necessary to enter the tank for operation, be sure to turn off the vehicle and pull out the key to prevent casualties caused by misoperation.

以上內容就是關于自動攪拌一體機http://klalyy.cn的介紹，希望這些內容對大家有所幫助。如果您還有什么疑問,或者想要了解更多資訊歡迎咨詢我們官網。我們將竭誠為您服務。

The above content is about the automatic mixing machine http://klalyy.cn I hope these contents will be helpful to you. If you have any questions or want more information, please consult our official website. We will serve you wholeheartedly.

上一頁：自動攪拌一體車磨合期需要注意那些事項？下一頁：自動上料一體機具有干式攪拌功能

熱門產品 / HOT PRODUCT